View Single Post
      07-10-2012, 02:44 AM   #56
Brigadier General
sparoz's Avatar

Drives: VO 1///M; Macan Turbo
Join Date: Jun 2008
Location: Sunshine Coast

iTrader: (0)

Originally Posted by Amnizu View Post
I'm pretty sure what your talking about is a non-linear torque curve due to turbo spool. This has very little to do with the throttle response of the car. You can make the gas pedal as twitchy as you want but it won't make any difference until the RPMs are high enough and the exhaust gas is creating enough pressure over the impeller blades to spin the turbo and force air into the throttle body. The 1M is actually a great example of this. M mode mainly remaps the throttle response to make the car "feel" faster many dyno's show there is little to no change in actual horsepower with M engaged.

Also, one can build a 350+ HP four cylinder turbo charged engine with a linear torque curve. Conceptually its fairly simple, you take a 2.0 to 2.5 liter cylinder motor tweak the compression ratio and install two turbos. One that has a low RPM operating efficiency and one that has a high RPM operating efficiency. You then tune them to roll off / on in sequence such that your torque curve remains mostly constant. A good engineer could even channel exhaust gas based on RPM to control spool and reduce lag and control heat and wastegate duty in the smaller turbo at high RPM.

In practicality this is more expensive, technically complex and difficult to maintain than traditional parallel turbo setups. In the past it has not made much sense to go this route due to these factors. In short, its easier to make those HP numbers with a V6 and two small turbos spinning at the same time. However, emissions standard and gas prices are forcing car builders to get creative with engine design and dual stage turbos is one option.

All that said, it can and has been done one example of a sequential twin turbo production car is the Mark IV Toyota supra.
He meant what he meant. You should watch some of his videos first - search for advevo in youtube. .
Macan S Diesel - Carrera White
Macan Turbo - White
1///M - Valencia Orange